FORD L8000 RECALLS
1995 FORD L8000 Recall
Item Affected: VEHICLE SPEED CONTROL
Date Announced: 08/02/1995
Description of Recall: THE HAND THROTTLE CABLE CAN WEAR THE BRASS SWIVEL BLOCK ON THE GOVERNOR LEVER THROUGH WHICH IT PASSES.
Conequence: THIS WEAR CAN RESULT IN THE GOVERNOR JAMMING IN THEDAMAGED SWIVEL AND COULD PREVENT THE GOVERNOR LEVER FROM RETURNING TO THE IDLE POSITION.
Action Need To Fix It: DEALERS WILL INSTALL A REVISED GOVERNOR LEVER WITH A STAINLESS STEEL SWIVEL. ALSO LETTERS WILL BE SENT TO VEHICLE OWNERS THAT HAVE THE SAME VEHICLES BUT DO NOT HAVE A FORD INSTALLED HAND THROTTLE ADVISING THEM THAT THEY MAY REQUIRE SERVICE IF THEY HAVE HAD AN AFTER MARKET HAND THROTTLE INSTALLED.
Notes: SYSTEM: FUEL; THROTTLE LINKAGES AND CONTROL. VEHICLE DESCRIPTION: TRUCKS, CHASSIS-CABS AND COWL-CHASSIS VEHICLES WITH INLINE FUEL INJECTION PUMP EQUIPPED FD-1060 OR FD-1460 ENGINES AND HAND THROTTLES. NOTE: THE VEHICLE BRAKES ARE CAPABLE OF OVERRIDING THE ENGINE POWER AND BRINGING THE VEHICLE TO A STOP. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLET IME, SHOULD CONTACT FORD AT 1-800-392-3673. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
1995 FORD L8000 Recall
Item Affected: SERVICE BRAKES, AIR:SUPPLY:HOSES, LINES/PIPING, AND FITTINGS
Date Announced: 06/13/1995
Description of Recall: AIR SYSTEM BLOCKAGE IN THE AIR DRYER OCCURS DEGRADING THE MOISTURE REMOVING CAPABILITIES OF THE DRYER WHEN THE VEHICLE IS OPERATED IN A COLD ENVIRONMENT AND MOISTURE ACCUMULATES AND FREEZES IN THE AIR DRYER OR IN THE LINE BETWEEN THE DRYER AND THE AIR SYSTEM RESERVOIR. THE AIR DRYER CAN BECOME OVERPRESSURIZED CAUSING THE AIR DRYER CARTRIDGE TO SEPARATE FROM THE MOUNTING BASE.
Conequence: IF THE AIR DRYER SEPARATES FROM THE BASE, THE CARTRIDGE CAN SEPARATE SUFFICIENTLY ENOUGH TO CAUSE PERSONAL INJURY OR PROPERTY DAMAGE.
Action Need To Fix It: DEALERS WILL EQUIP AIR SYSTEMS WITH A PRESSURE RELIEF VALVE TO BE LOCATED BETWEEN THE COMPRESSOR AND THE AIR DRYER. THIS PRESSURE RELIEF VALVE IS INTENDED TO VENT IF EXCESSIVE PRESSURE DEVELOPS IN THE AIR DRYER.
Notes: SYSTEM: BRAKES; AIR DRYER.VEHICLE DESCRIPTION: TRUCKS AND CHASSIS-CAB VEHICLES EQUIPPED WITH AIR BRAKES AND ROCKWELL WABCO SYSTEM SAVER "1000" AIR DRYER. NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED FREE OF CHARGE WITHIN A REASONABLE TIME, CONTACT ROCKWELL WABCO AT 1-800-535-5560 OR FORD AT 1-800-392-3673. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
1994 FORD L8000 Recall
Item Affected: VEHICLE SPEED CONTROL
Date Announced: 08/02/1995
Description of Recall: THE HAND THROTTLE CABLE CAN WEAR THE BRASS SWIVEL BLOCK ON THE GOVERNOR LEVER THROUGH WHICH IT PASSES.
Conequence: THIS WEAR CAN RESULT IN THE GOVERNOR JAMMING IN THEDAMAGED SWIVEL AND COULD PREVENT THE GOVERNOR LEVER FROM RETURNING TO THE IDLE POSITION.
Action Need To Fix It: DEALERS WILL INSTALL A REVISED GOVERNOR LEVER WITH A STAINLESS STEEL SWIVEL. ALSO LETTERS WILL BE SENT TO VEHICLE OWNERS THAT HAVE THE SAME VEHICLES BUT DO NOT HAVE A FORD INSTALLED HAND THROTTLE ADVISING THEM THAT THEY MAY REQUIRE SERVICE IF THEY HAVE HAD AN AFTER MARKET HAND THROTTLE INSTALLED.
Notes: SYSTEM: FUEL; THROTTLE LINKAGES AND CONTROL. VEHICLE DESCRIPTION: TRUCKS, CHASSIS-CABS AND COWL-CHASSIS VEHICLES WITH INLINE FUEL INJECTION PUMP EQUIPPED FD-1060 OR FD-1460 ENGINES AND HAND THROTTLES. NOTE: THE VEHICLE BRAKES ARE CAPABLE OF OVERRIDING THE ENGINE POWER AND BRINGING THE VEHICLE TO A STOP. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLET IME, SHOULD CONTACT FORD AT 1-800-392-3673. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
1994 FORD L8000 Recall
Item Affected: SERVICE BRAKES, AIR:SUPPLY:HOSES, LINES/PIPING, AND FITTINGS
Date Announced: 06/13/1995
Description of Recall: AIR SYSTEM BLOCKAGE IN THE AIR DRYER OCCURS DEGRADING THE MOISTURE REMOVING CAPABILITIES OF THE DRYER WHEN THE VEHICLE IS OPERATED IN A COLD ENVIRONMENT AND MOISTURE ACCUMULATES AND FREEZES IN THE AIR DRYER OR IN THE LINE BETWEEN THE DRYER AND THE AIR SYSTEM RESERVOIR. THE AIR DRYER CAN BECOME OVERPRESSURIZED CAUSING THE AIR DRYER CARTRIDGE TO SEPARATE FROM THE MOUNTING BASE.
Conequence: IF THE AIR DRYER SEPARATES FROM THE BASE, THE CARTRIDGE CAN SEPARATE SUFFICIENTLY ENOUGH TO CAUSE PERSONAL INJURY OR PROPERTY DAMAGE.
Action Need To Fix It: DEALERS WILL EQUIP AIR SYSTEMS WITH A PRESSURE RELIEF VALVE TO BE LOCATED BETWEEN THE COMPRESSOR AND THE AIR DRYER. THIS PRESSURE RELIEF VALVE IS INTENDED TO VENT IF EXCESSIVE PRESSURE DEVELOPS IN THE AIR DRYER.
Notes: SYSTEM: BRAKES; AIR DRYER.VEHICLE DESCRIPTION: TRUCKS AND CHASSIS-CAB VEHICLES EQUIPPED WITH AIR BRAKES AND ROCKWELL WABCO SYSTEM SAVER "1000" AIR DRYER. NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED FREE OF CHARGE WITHIN A REASONABLE TIME, CONTACT ROCKWELL WABCO AT 1-800-535-5560 OR FORD AT 1-800-392-3673. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
1993 FORD L8000 Recall
Item Affected: WHEELS
Date Announced: 11/10/1992
Description of Recall:
Conequence: USING THE WRONG SIZED CLAMPS TO ATTACH THE RIM AND TIREASSEMBLY TO THE WHEEL SPOKES COULD CAUSE THE STUDS THAT ATTACH THE CLAMPS TO THESPOKES TO BEND. IF THE STUDS ARE BENT, THERE IS AN INCREASED RISK OF STUDFRACTURE THAT COULD RESULT IN THE RIM AND TIRE ASSEMBLY BREAKING FROM THEWHEEL.
Action Need To Fix It: REPLACE THE CLAMPS AND STUDS ON THE CAST SPOKE WHEELS.
Notes: SYSTEM: WHEELS.VEHICLE DESCRIPTION: INCOMPLETE 6000 TO 12000 POUND FRONT GAWR CHASSIS-CABVEHICLES EQUIPPED WITH CAST SPOKE WHEELS.DECRIPTION OF DEFECT: ONE OR MORE OF THE SIX CLAMPS THAT HOLD THE TIRE AND RIMASSEMBLY TO THE CAST SPOKES OF THE FRONT WHEEL MAY HAVE BEEN OF AN INCORRECTSIZE.NOTE: THE F150, F250, F350, F-SUPER DUTY, AND THE BRONCO VEHICLES ARE NOTINVOLVED IN THIS RECALL CAMPAIGN.
1993 FORD L8000 Recall
Item Affected: VEHICLE SPEED CONTROL:SPRINGS
Date Announced: 09/27/1993
Description of Recall: AS A RESULT OF INHERENT VIBRATION IN THESE ENGINES, THE THROTTLE RETURN SPRINGS CAN FRACTURE.
Conequence: IF ONE OF THE TWO RETURN SPRINGS FRACTURES WHILE THEVEHICLE IS BEING DRIVEN, A SUBSTANTIAL REDUCTION IN ACCELERATOR PEDAL EFFORTWOULD BE FELT. IF THE SECOND SPRING ALSO FRACTURES, THE THROTTLE WOULD NOTRETURN TO IDLE POSITION AND CAN RESULT IN INCREASED ENGINE SPEED AND THEPOSSIBILITY OF LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Action Need To Fix It: THE THROTTLE RETURN CONTROL SYSTEM WITH THE COIL TORSION SPRING DESIGN WILL BE REPLACED.
Notes: SYSTEM: FUEL: THROTTLE LINKAGES AND CONTROL RETURN SPRING.VEHICLE DESCRIPTION: MEDIUM AND HEAVY TRUCKS, TRUCK CHASSIS, AND BUS CHASSISEQUIPPED WITH CUMMINS 5.9L AND 8.3L DIESEL ENGINES WITH IN-LINE FUEL INJECTIONPUMPS.NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPONSERVICE DATE AND THE REMEDY IS NOT PROVIDED WITHIN A REASONABLE TIME AND FREEOF CHARGE OR THE REMEDY IS DOES NOT CORRECT THE DEFECT OR NONCOMPLIANCE, PLEASECONTACT THE FORD SERVICE CENTER AT 1-800-392-3673. ALSO, CONTACT THE NATIONALHIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
1993 FORD L8000 Recall
Item Affected: VEHICLE SPEED CONTROL
Date Announced: 08/02/1995
Description of Recall: THE HAND THROTTLE CABLE CAN WEAR THE BRASS SWIVEL BLOCK ON THE GOVERNOR LEVER THROUGH WHICH IT PASSES.
Conequence: THIS WEAR CAN RESULT IN THE GOVERNOR JAMMING IN THEDAMAGED SWIVEL AND COULD PREVENT THE GOVERNOR LEVER FROM RETURNING TO THE IDLE POSITION.
Action Need To Fix It: DEALERS WILL INSTALL A REVISED GOVERNOR LEVER WITH A STAINLESS STEEL SWIVEL. ALSO LETTERS WILL BE SENT TO VEHICLE OWNERS THAT HAVE THE SAME VEHICLES BUT DO NOT HAVE A FORD INSTALLED HAND THROTTLE ADVISING THEM THAT THEY MAY REQUIRE SERVICE IF THEY HAVE HAD AN AFTER MARKET HAND THROTTLE INSTALLED.
Notes: SYSTEM: FUEL; THROTTLE LINKAGES AND CONTROL. VEHICLE DESCRIPTION: TRUCKS, CHASSIS-CABS AND COWL-CHASSIS VEHICLES WITH INLINE FUEL INJECTION PUMP EQUIPPED FD-1060 OR FD-1460 ENGINES AND HAND THROTTLES. NOTE: THE VEHICLE BRAKES ARE CAPABLE OF OVERRIDING THE ENGINE POWER AND BRINGING THE VEHICLE TO A STOP. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLET IME, SHOULD CONTACT FORD AT 1-800-392-3673. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
1993 FORD L8000 Recall
Item Affected: SERVICE BRAKES, AIR:SUPPLY:HOSES, LINES/PIPING, AND FITTINGS
Date Announced: 06/13/1995
Description of Recall: AIR SYSTEM BLOCKAGE IN THE AIR DRYER OCCURS DEGRADING THE MOISTURE REMOVING CAPABILITIES OF THE DRYER WHEN THE VEHICLE IS OPERATED IN A COLD ENVIRONMENT AND MOISTURE ACCUMULATES AND FREEZES IN THE AIR DRYER OR IN THE LINE BETWEEN THE DRYER AND THE AIR SYSTEM RESERVOIR. THE AIR DRYER CAN BECOME OVERPRESSURIZED CAUSING THE AIR DRYER CARTRIDGE TO SEPARATE FROM THE MOUNTING BASE.
Conequence: IF THE AIR DRYER SEPARATES FROM THE BASE, THE CARTRIDGE CAN SEPARATE SUFFICIENTLY ENOUGH TO CAUSE PERSONAL INJURY OR PROPERTY DAMAGE.
Action Need To Fix It: DEALERS WILL EQUIP AIR SYSTEMS WITH A PRESSURE RELIEF VALVE TO BE LOCATED BETWEEN THE COMPRESSOR AND THE AIR DRYER. THIS PRESSURE RELIEF VALVE IS INTENDED TO VENT IF EXCESSIVE PRESSURE DEVELOPS IN THE AIR DRYER.
Notes: SYSTEM: BRAKES; AIR DRYER.VEHICLE DESCRIPTION: TRUCKS AND CHASSIS-CAB VEHICLES EQUIPPED WITH AIR BRAKES AND ROCKWELL WABCO SYSTEM SAVER "1000" AIR DRYER. NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED FREE OF CHARGE WITHIN A REASONABLE TIME, CONTACT ROCKWELL WABCO AT 1-800-535-5560 OR FORD AT 1-800-392-3673. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
1990 FORD L8000 Recall
Item Affected: SERVICE BRAKES, AIR:CONTROLS
Date Announced: 06/25/1990
Description of Recall: SECONDARY SERVICE RESERVOIR AIR CHECK VALVES MAY NOT SEAT PROPERLY DUE TO A MECHANICAL INTERFERENCE CONDITION BETWEEN A CIRCULAR BRASS GUIDE AND THE WALL OF A CYLINDRICAL FERRULE IN WHICH THE BRASS GUIDE IS INTENDED TO MOVE FREELY.
Conequence: IN THE EVENT OF PRESSURE LOSS IN THE SUPPLY RESERVOIR,A DEFECTIVE CHECK VALVE WOULD ALLOW PRESSURE EQUALIZATION BETWEEN PRIMARY ANDSECONDARY SERVICE RESERVOIRS, PRESENTING THE POTENTIAL FOR LOSS OR ABSENCE OFFRONT BRAKING ABILITY, WHICH COULD CAUSE LOSS OF CONTROL AND AN ACCIDENT.
Action Need To Fix It: INSTALL REVISED DESIGN SECONDARY SERVICE RESERVOIR CHECK VALVE COMPONENTS.
Notes: SYSTEM: AIR PRESSURE CHECK VALVES.VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS AND CHASSIS CABS.
1989 FORD L8000 Recall
Item Affected: SERVICE BRAKES, AIR:CONTROLS
Date Announced: 06/25/1990
Description of Recall: SECONDARY SERVICE RESERVOIR AIR CHECK VALVES MAY NOT SEAT PROPERLY DUE TO A MECHANICAL INTERFERENCE CONDITION BETWEEN A CIRCULAR BRASS GUIDE AND THE WALL OF A CYLINDRICAL FERRULE IN WHICH THE BRASS GUIDE IS INTENDED TO MOVE FREELY.
Conequence: IN THE EVENT OF PRESSURE LOSS IN THE SUPPLY RESERVOIR,A DEFECTIVE CHECK VALVE WOULD ALLOW PRESSURE EQUALIZATION BETWEEN PRIMARY ANDSECONDARY SERVICE RESERVOIRS, PRESENTING THE POTENTIAL FOR LOSS OR ABSENCE OFFRONT BRAKING ABILITY, WHICH COULD CAUSE LOSS OF CONTROL AND AN ACCIDENT.
Action Need To Fix It: INSTALL REVISED DESIGN SECONDARY SERVICE RESERVOIR CHECK VALVE COMPONENTS.
Notes: SYSTEM: AIR PRESSURE CHECK VALVES.VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS AND CHASSIS CABS.
SOME FORD L8000 FOR SALE
Mileage: 85949
Color: Orange
Transmission: Automatic
Body Style: Pickup
City: Salem, NH
Engine Type: Select
